Clay tiles are colorfast which means their tints improve rather than fade over time.
Minimum roof deck slope for the installation of clay tile.
Asphalt shingles continue to be the most widely installed roof covering option in north america.
Clay and concrete roof tiles can only be installed on roof slopes of 2 1 2 12 or greater.
Clay and concrete tile minimum roof slope roof pitch r905 3 2.
The minimum roof slope allowed by code for any type of roof is in 12 applicable only to coal tar pitch roof systems.
This article series explains clay tile roofing types clay roofing tile inspection tile roofing diagnosis tile roof repair.
Over roof edges design and installation of roof drainage sys tems shall comply with section 1503 and the florida building.
Refer to manufacturer s installation instructions frsa tri florida high wind concrete and clay roof tile installation manual fifth edition where the v asd is determined in accordance with section r301 2 1 3 or ras 118 119 or 120 for underlayment and slope requirements for specific roof tile systems.
On clay and concrete tile roof coverings shall be in accordance with section 1609 5.
This means for every 12 horizontal units the roof must rise a minimum of two and one half vertical units.
About minimum slope allowed for clay tile roofs or other tile roofs if you read through standards such as icc es esr2015 concrete and clay roof tile installation manual for moderate climates copy on file you ll see that there is no prohibition of clay tiles on low slope roofs.
Tile covered roof installation specifications adapted paraphrased with permission from best practices guide to residential construction chapter on best roofing practices.
It is uncommon to find a roof below 15 but for those very low pitch applications there are interlocking clay pantiles available suitable for use down to 12 5.
The following table provides the minimum required allowable roof slope for each type of roofing material mentioned in the code.
Ratios from that minimum up to 4 12 which are considered low pitch require double underlayment.
The irc recommends a minimum pitch of 2 5 12 for these materials.
The short simple answer is 2 12 has traditionally been considered the absolute minimum acceptable roof slope suitable for asphalt shingles.
Traditionally a minimum roof pitch of 20 was recommended in bs 5534 but modern tiles and slates have now been designed for applications as low as 15.
Concrete is long lasting with a minimum lifespan of 50 years depending on climate.
